歡迎訪問濟南金昊化工有限公司網站!
全國咨詢熱線:13869119097

聯系我們

濟南金昊化工有限公司

電話:13869119097

傳真:0531-88529097

售后:0531-88529097

地址:濟南市天橋區桑梓店鎮化工市場南區

新聞中心

所在位置:首頁 > 新聞中心 

順酐的生產工藝及用途

發布來源:http://www.shrisa.cn    更新時間:2023-01-31 點擊數:284

什么是順酐?順酐又稱順丁烯二酸酐,馬來酸酐,2,5-呋喃二酮等。斜方晶系無色針狀或片狀晶體。有強烈刺激氣味,溶于乙醇、乙醚和丙酮,難溶于石油醚和四氯化碳。與熱水作用而成馬來酸。主要用于生產不飽和聚酯樹脂、醇酸樹脂、農藥馬拉硫磷、低毒農藥4049、長效碘胺的原料。
What is maleic anhydride? Maleic anhydride is also known as maleic anhydride, maleic anhydride, 2,5-furanedione, etc. Orthorhombic crystals are colorless needle-shaped or flaky crystals. It has a strong pungent smell and is soluble in ethanol, ether and acetone, but insoluble in petroleum ether and carbon tetrachloride. It reacts with hot water to form maleic acid. It is mainly used as raw material for the production of unsaturated polyester resin, alkyd resin, pesticide malathion, high-efficiency and low-toxicity pesticide 4049, and long-acting iodamine.
順酐的生產工藝:
Production process of maleic anhydride:
1、苯氧化法
1. Benzene oxidation method
苯氧化為順酐是在催化劑存在下進行的。常用催化劑的活性組分均為釩的氧化物(見金屬氧化物催化劑),為抑制苯被完全氧化,常加入鉬、磷、鈦、鎢、銀及堿金屬等元素的氧化物為添加劑,并采用低比表面的惰性物質為催化劑載體,如α-氧化鋁、剛玉等。反應在常壓下進行,溫度350~400℃。
The oxidation of benzene to maleic anhydride is carried out in the presence of catalyst. The active components of common catalysts are vanadium oxides (see metal oxide catalysts). In order to inhibit the complete oxidation of benzene, oxides of molybdenum, phosphorus, titanium, tungsten, silver and alkali metals are often added as additives, and inert substances with low specific surface are used as catalyst carriers, such as α- Alumina, corundum, etc. The reaction is carried out under normal pressure at 350~400 ℃.
工藝過程由苯的氧化,順酐的分離和提純兩大部分組成。苯蒸氣和空氣能形成爆炸混合物,所以進入反應器的混合氣中,苯的濃度應在爆炸限之外,一般為1%~1.4%(摩爾)。
The process consists of oxidation of benzene, separation and purification of maleic anhydride. Benzene vapor and air can form explosive mixture, so the concentration of benzene in the mixed gas entering the reactor should be outside the explosion limit, generally 1%~1.4% (mol).
苯氧化為強放熱反應,工業上常采用列管式固定床反應器,有很大的傳熱面,管外為冷卻系統,反應熱可用于產生高壓蒸汽。離開反應器的氣體中含順酐約1%(摩爾),用冷卻的辦法可將其中所含一半左右的順酐冷凝為液體,其余部分則用吸收法回收。
Benzene oxidation is a strong exothermic reaction. In industry, tubular fixed-bed reactors are often used, with large heat transfer surface. The outside of the tube is a cooling system, and the reaction heat can be used to generate high-pressure steam. The gas leaving the reactor contains about 1% (mol) of maleic anhydride. About half of the maleic anhydride can be condensed into liquid by cooling, and the rest can be recovered by absorption.
吸收劑用水或惰性有機溶劑,大多數工廠采用的是水。所得到的吸收液是順丁烯二酸的水溶液,濃度35%~40%(質量),需用共沸溶劑(例如二甲苯、苯甲醚)進行脫水,把酸重新轉化成酸酐。脫水也可在膜式蒸發器中進行。粗酐經減壓精餾可得成品。以苯計算,整個過程的順酐收率為92%~96%(質量)。
Absorbent water or inert organic solvent, most plants use water. The obtained absorption solution is an aqueous solution of maleic acid with a concentration of 35%~40% (mass). It needs to be dehydrated with azeotropic solvents (such as xylene and anisole) to convert the acid back into anhydride. Dehydration can also be carried out in membrane evaporator. Crude anhydride can be obtained by vacuum distillation. Based on benzene, the yield of maleic anhydride in the whole process is 92%~96% (mass).
2、C4烴氧化法
2. C4 hydrocarbon oxidation method
正丁烷與丁烯均含有與順酐相同的碳原子數,是生產順酐的理想原料。由于正丁烷較其他原料低廉,用正丁烷更為有利。其流程與苯氧化法基本相同,催化劑為釩-磷-氧體系,添加劑有鐵、鉛、鋅、銅、銻等元素的氧化物。
Both n-butane and butene contain the same carbon atoms as maleic anhydride, and are ideal raw materials for the production of maleic anhydride. Because the price of n-butane is lower than other raw materials, it is more advantageous to use n-butane. The process is basically the same as that of benzene oxidation. The catalyst is vanadium - phosphorus - oxygen system, and the additives are oxides of iron, lead, zinc, copper, antimony and other elements.
可用固定床反應器或用流化床反應器,反應溫度約400℃。正丁烷-空氣混合物中正丁烷濃度為1.0%~1.6%(摩爾)。整個過程的順酐收率按正丁烷計約為50%。
Fixed bed reactor or fluidized bed reactor can be used, and the reaction temperature is about 400 ℃. The concentration of n-butane in the n-butane-air mixture is 1.0%~1.6% (mol). The yield of maleic anhydride in the whole process is about 50% based on n-butane.
由于C4烴氧化的選擇性較低,因此設備投資較以苯為原料時為高,且后加工不能采用部分冷凝,而必須將反應氣體中的順酐全部用吸收法回收,從而使能耗加大。
Due to the low selectivity of C4 hydrocarbon oxidation, the equipment investment is higher than that when benzene is used as raw material, and partial condensation cannot be used for post-processing. Instead, all maleic anhydride in the reaction gas must be recovered by absorption method, thus increasing energy consumption.
順酐主要用于生產不飽和聚酯樹脂、醇酸樹脂、農藥馬拉硫磷、低毒農藥4049、長效碘胺的原料。也是涂料、馬來松香、聚馬來酐、順酐-苯乙烯共聚物的共聚單體,也是生產油墨助劑、造紙助劑、增塑劑、酒石酸、富馬酸、四氫呋喃等的有機化工原料。您有需求可以四十來我們完網站http://www.shrisa.cn咨詢!
Maleic anhydride is mainly used as raw material for the production of unsaturated polyester resin, alkyd resin, pesticide malathion, high-efficiency and low-toxicity pesticide 4049, and long-acting iodamine. It is also a comonomer of paint, maleic rosin, polymaleic anhydride, maleic anhydride-styrene copolymer, and an organic chemical raw material for the production of ink additives, paper additives, plasticizers, tartaric acid, fumaric acid, tetrahydrofuran, etc. If you need, you can come to our website at forty http://www.shrisa.cn consulting service

聯系我們

濟南金昊化工有限公司

電話:13869119097

傳真:0531-88529097

售后:0531-88529097

地址:濟南市天橋區桑梓店鎮化工市場南區

掃描二維碼,關注我們

13869119097

全國客戶服務熱線

濟南金昊化工有限公司

備案號:魯ICP備19046505號-2
主站蜘蛛池模板: 博莱特空压机|博莱特-阿特拉斯独资空压机品牌核心代理商 | 商标转让-商标注册-商标查询-软著专利服务平台 - 赣江万网 | 闭端端子|弹簧螺式接线头|防水接线头|插线式接线头|端子台|电源线扣+护线套|印刷电路板型端子台|金笔电子代理商-上海拓胜电气有限公司 | 商用绞肉机-熟肉切片机-冻肉切丁机-猪肉开条机 - 广州市正盈机械设备有限公司 | 网带通过式抛丸机,,网带式打砂机,吊钩式,抛丸机,中山抛丸机生产厂家,江门抛丸机,佛山吊钩式,东莞抛丸机,中山市泰达自动化设备有限公司 | 世界箱包品牌十大排名,女包小众轻奢品牌推荐200元左右,男包十大奢侈品牌排行榜双肩,学生拉杆箱什么品牌好质量好 - Gouwu3.com | 耙式干燥机_真空耙式干燥机厂家-无锡鹏茂化工装备有限公司 | 集菌仪厂家_全封闭_封闭式_智能智能集菌仪厂家-上海郓曹 | 玻纤土工格栅_钢塑格栅_PP焊接_单双向塑料土工格栅_复合防裂布厂家_山东大庚工程材料科技有限公司 | 高效节能电机_伺服主轴电机_铜转子电机_交流感应伺服电机_图片_型号_江苏智马科技有限公司 | 赛默飞Thermo veritiproPCR仪|ProFlex3 x 32PCR系统|Countess3细胞计数仪|371|3111二氧化碳培养箱|Mirco17R|Mirco21R离心机|仟诺生物 | 防水套管厂家_刚性防水套管_柔性防水套管_不锈钢防水套管-郑州中泰管道 | 药品仓库用除湿机-变电站用防爆空调-油漆房用防爆空调-杭州特奥环保科技有限公司 | 密封无忧网 _ 专业的密封产品行业信息网 | 烟气在线监测系统_烟气在线监测仪_扬尘检测仪_空气质量监测站「山东风途物联网」 | IP检测-检测您的IP质量| 冷油器,取样冷却器,热力除氧器-连云港振辉机械设备有限公司 | 雾度仪_雾度计_透光率雾度仪价格-三恩时(3nh)光电雾度仪厂家 | 驾驶式洗地机/扫地机_全自动洗地机_工业洗地机_荣事达工厂官网 | PC构件-PC预制构件-构件设计-建筑预制构件-PC构件厂-锦萧新材料科技(浙江)股份有限公司 | 中红外QCL激光器-其他连续-半导体连续激光器-筱晓光子 | 仿真茅草_人造茅草瓦价格_仿真茅草厂家_仿真茅草供应-深圳市科佰工贸有限公司 | 炭黑吸油计_测试仪,单颗粒子硬度仪_ASTM标准炭黑自销-上海贺纳斯仪器仪表有限公司(HITEC中国办事处) | 3d可视化建模_三维展示_产品3d互动数字营销_三维动画制作_3D虚拟商城 【商迪3D】三维展示服务商 广东健伦体育发展有限公司-体育工程配套及销售运动器材的体育用品服务商 | 河北凯普威医疗器材有限公司,高档轮椅系列,推车系列,座厕椅系列,协步椅系列,拐扙系列,卫浴系列 | LINK FASHION 童装·青少年装展 河南卓美创业科技有限公司-河南卓美防雷公司-防雷接地-防雷工程-重庆避雷针-避雷器-防雷检测-避雷带-避雷针-避雷塔、机房防雷、古建筑防雷等-山西防雷公司 | 全钢实验台,实验室工作台厂家-无锡市辰之航装饰材料有限公司 | 电子厂招聘_工厂招聘_普工招聘_小时工招聘信息平台-众立方招工网 | 广州迈驰新GMP兽药包装机首页_药品包装机_中药散剂包装机 | 臭氧老化试验箱,高低温试验箱,恒温恒湿试验箱,防水试验设备-苏州亚诺天下仪器有限公司 | 山东聚盛新型材料有限公司-纳米防腐隔热彩铝板和纳米防腐隔热板以及钛锡板、PVDF氟膜板供应商 | HEYL硬度计量泵-荧光法在线溶解氧仪-净时测控技术(上海)有限公司 | 不锈钢复合板厂家_钛钢复合板批发_铜铝复合板供应-威海泓方金属复合材料股份有限公司 | Safety light curtain|Belt Sway Switches|Pull Rope Switch|ultrasonic flaw detector-Shandong Zhuoxin Machinery Co., Ltd | 砂石生产线_石料生产线设备_制砂生产线设备价格_生产厂家-河南中誉鼎力智能装备有限公司 | 废气处理_废气处理设备_工业废气处理_江苏龙泰环保设备制造有限公司 | 自动钻孔机-全自动数控钻孔机生产厂家-多米(广东)智能装备有限公司 | 控显科技 - 工控一体机、工业显示器、工业平板电脑源头厂家 | 青岛美佳乐清洁工程有限公司|青岛油烟管道清洗|酒店|企事业单位|学校工厂厨房|青岛油烟管道清洗 插针变压器-家用电器变压器-工业空调变压器-CD型电抗器-余姚市中驰电器有限公司 | 山楂片_雪花_迷你山楂片_山楂条饼厂家-青州市丰源食品厂 | 防水套管厂家-柔性防水套管-不锈钢|刚性防水套管-天翔管道 |